Quantum 610 Owner's Manual Page 1

Owner’s Manual1-800-800-8586 (Exeter, PA) • 1-888-570-1113 (St. Catharines, ON) • www.quantumrehab.com

10 www.quantumrehab.com Quantum 610II. SAFETYFigure 1. Maximum Safe Slope (Ascending and Descending)WARNING! Even though your power chair is capable o

Quantum 610 www.quantumrehab.com 11II. SAFETYFreewheel ModeYour power chair is equipped with two manual freewheel levers to allow for

12 www.quantumrehab.com Quantum 610II. SAFETYTransfersTransferring onto and off of your power chair requires agood sense of balance. Always have an at

Quantum 610 www.quantumrehab.com 13II. SAFETYInclement Weather PrecautionsExposure of your power chair to inclement weather condition

14 www.quantumrehab.com Quantum 610II. SAFETYBatteriesIn addition to following the warnings below, be sure to comply with all other battery handling i

Quantum 610 www.quantumrehab.com 15Electromagnetic and Radio Frequency Interference (EMI/RFI)WARNING! Laboratory tests have shown tha

16 www.quantumrehab.com Quantum 610III. YOUR POWER CHAIRTHE QUANTUM 610The Quantum 610 has two main assemblies: the seat assembly and the power base a

Quantum 610 www.quantumrehab.com 17III. YOUR POWER CHAIRQUANTUM 610 SPECIFICATIONSSuspension: Active-Trac Extreme (ATX)Drive Wheels:

18 www.quantumrehab.com Quantum 610III. YOUR POWER CHAIRELECTRICAL COMPONENTSThe electrical components are located inside the power base. The ammeter

Quantum 610 www.quantumrehab.com 19III. YOUR POWER CHAIRBattery Connector: This is where the controller connects to the batteries.Cha

www.quantumrehab.com Quantum 610SAFETY GUIDELINESCopyright © 2006Pride Mobility Products Corp.INFMANU2924/RevB/January06The symbols below are used thr

20 www.quantumrehab.com Quantum 610Manual Freewheel LeversThe Quantum 610 has a manual freewheel lever on each motor. Manual freewheel levers enable y

Quantum 610 www.quantumrehab.com 21INITIAL ASSEMBLYYour power chair may require some assembly either before initial use or after tran

22 www.quantumrehab.com Quantum 610IV. ASSEMBLYSeat InstallationIt may be necessary to install the seat either prior to initialoperation or after tran

Quantum 610 www.quantumrehab.com 23WIRE TIESFigure 13. Remote Plus Controller Routed on aContour SeatPower Seat Option InstallationYo

24 www.quantumrehab.com Quantum 610V. COMFORT ADJUSTMENTSCOMFORT ADJUSTMENTSAfter becoming familiar with your power chair’s operation, you may find th

Quantum 610 www.quantumrehab.com 25Figure 18. Seatback Angle AdjustmentFigure 17. Seat Position AdjustmentV. COMFORT ADJUSTMENTS14. R

26 www.quantumrehab.com Quantum 610Figure 20. Underside of Armrest (Contour Seat)SETSCREWArmrest Width AdjustmentYou can change each armrest’s width i

Quantum 610 www.quantumrehab.com 27V. COMFORT ADJUSTMENTS10. Plug the controller connector(s) into the power base.11. Reinstall the r

28 www.quantumrehab.com Quantum 610V. COMFORT ADJUSTMENTS2. Loosen the jam nut.3. Turn the setscrew counterclockwise to raise the frontof the foot pla

Quantum 610 www.quantumrehab.com 29ACDBBCDAFigure 27. Multi-Axis Foot Plate (ELR Shown)V. COMFORT ADJUSTMENTSSETSCREW LOCATIONTo adj

Quantum 610 www.quantumrehab.com 3I. INTRODUCTION...

30 www.quantumrehab.com Quantum 610V. COMFORT ADJUSTMENTSPower Elevating Seat (Optional)If your power chair is equipped with a power elevating seat, y

Quantum 610 www.quantumrehab.com 31VI. BATTERIES AND CHARGINGBATTERIES AND CHARGINGThe Quantum 610 uses two long-lasting, 12-volt, de

32 www.quantumrehab.com Quantum 610VI. BATTERIES AND CHARGINGWARNING! Prevent injury and/or equipment damage! If your off-board battery charger has no

Quantum 610 www.quantumrehab.com 33VI. BATTERIES AND CHARGINGFrequently Asked Questions (FAQs)How does the charger work?The battery c

34 www.quantumrehab.com Quantum 610WARNING! Corrosive chemicals contained in batteries. Use only AGM or Gel-Cell batteries toreduce the risk of leakag

Quantum 610 www.quantumrehab.com 35VII. OPERATIONFigure 29. FLIGHT Controller23451FLIGHT CONTROLLERThe electronic controller is what

36 www.quantumrehab.com Quantum 610VII. OPERATIONFigure 30. FLIGHT Controller KeypadOn/Off KeyThe on/off key turns the FLIGHT on and off.WARNING! Unle

Quantum 610 www.quantumrehab.com 37VII. OPERATIONSpeed KeysThere are two keys that control the speed. Press the hare key to increase

38 www.quantumrehab.com Quantum 610VII. OPERATIONVSI ELECTRONIC CONTROLLERThe electronic controller is what you use to operate your power chair. The e

Quantum 610 www.quantumrehab.com 39Figure 32. VSI Controller KeypadVII. OPERATIONKeypadThe keypad is located in front of the joystick

4 www.quantumrehab.com Quantum 610I. INTRODUCTIONSAFETYWELCOME to Quantum Rehab, a division of Pride Mobility Products Corporation (Pride). The power

40 www.quantumrehab.com Quantum 610VII. OPERATIONActuator Keys and Actuator Lights (For Optional Equipment)Actuator keys and actuator lights are used

Quantum 610 www.quantumrehab.com 41VII. OPERATIONCharger Inhibit Connector (Optional)The charger inhibit connector connects the VSI t

42 www.quantumrehab.com Quantum 610VII. OPERATIONREMOTE PLUS CONTROLLERThe electronic controller is what you use to operate your power chair. The elec

Quantum 610 www.quantumrehab.com 43VII. OPERATIONMode Key (Speed Settings)The mode key controls the speed settings. The Remote Plussp

44 www.quantumrehab.com Quantum 610VII. OPERATIONNOTE: When the batteries approach a discharged state, the first red light will begin to slowly flash,

Quantum 610 www.quantumrehab.com 45VII. OPERATIONRemote Plus Error CodesIn addition to indicating the current state of battery charge

46 www.quantumrehab.com Quantum 610THE MICRODRIVE CONTROLLERThe electronic controller is what you use to operate your power chair. It takes the batter

Quantum 610 www.quantumrehab.com 47Profile and Speed IndicatorThe profile and speed indicator is a 5-segment illumi-nated display tha

48 www.quantumrehab.com Quantum 610Drive Profile SelectionYour Microdrive controller may be programmed for more than one drive profile that allows the

Quantum 610 www.quantumrehab.com 49 FLASHING LIGHTS DIAGNOSIS SOLUTION 10

Quantum 610 www.quantumrehab.com 5I. INTRODUCTIONPRIDE OWNERS CLUBAs an owner of a Pride product, you are invited to register your pr

50 www.quantumrehab.com Quantum 610VIII. CARE AND MAINTENANCECARE AND MAINTENANCEYour Quantum 610 is a sophisticated power chair. Like any motorized v

Quantum 610 www.quantumrehab.com 51VIII. CARE AND MAINTENANCE! The body shroud has been sprayed with a clear sealant coating. You can

52 www.quantumrehab.com Quantum 610VIII. CARE AND MAINTENANCEStorageYour power chair should be stored in a dry place, free from temperature extremes.

Quantum 610 www.quantumrehab.com 53VIII. CARE AND MAINTENANCE8. Reassemble the rim halves and reinstall the nuts and washers to the w

54 www.quantumrehab.com Quantum 610BATTERY WIRING DIAGRAM LABELVIII. CARE AND MAINTENANCEFigure 39. Battery InstallationREAR SHROUD FASTENERSREAR SHRO

Quantum 610 www.quantumrehab.com 55VIII. CARE AND MAINTENANCEWhen to See Your Quantum Rehab Specialist for ServiceThe following sympt

56 www.quantumrehab.com Quantum 610IX. WARRANTYLIFETIME LIMITED WARRANTYFor the lifetime of your power chair from the date of purchase, Pride will rep

Quantum 610 www.quantumrehab.com 57IX. WARRANTYRECONDITIONED UNITS WARRANTYAll reconditioned units are covered by a six-month warrant

58 www.quantumrehab.com Quantum 610NOTES

Pride keeps a more detailed report on file at the factory.Date InspectedInspectorThank you formaking theQuantum 610 yourchoice in powerchairs.We havet

6 www.quantumrehab.com Quantum 610II. SAFETYCorrosive chemicals contained in battery. Use only AGM or Gel-Cell batteries toreduce the risk of leakage

Quantum 610 www.quantumrehab.com 7II. SAFETYDo not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operatin

8 www.quantumrehab.com Quantum 610II. SAFETYSAFETYMANDATORY! Do not operate your new power chair for the first time without completely readingand unde

Quantum 610 www.quantumrehab.com 9II. SAFETYWeight LimitationsYour power chair is rated for a maximum weight capacity. Please refer t